+- Woodnet Forums (https://forums.woodnet.net)
+-- Thread: Spray shellac & lacquer - acceptable lowest temperatures? (/showthread.php?tid=7172668)
Spray shellac & lacquer - acceptable lowest temperatures? - giradman - 12-20-2015
Hello all - I'm building two oak wall cabinets that will hold 8 horizontal pieces for name badges (local church fellowship) - the units are 18" x 40" - I'm thinking about finishing options w/ the weather getting colder - brushing would be sloppy w/ all of the smaller pieces - I could wipe on a finish in the heated basement - bought several cans of spray shellac for the initial coat and then spray lacquer (also have some spray poly) - however, I really do not want to spray in the basement w/ the types of volatiles in these cans - what would be the lowest temps to spray outside (was 50 F today). Thanks for any suggestions - Dave
Re: Spray shellac & lacquer - acceptable lowest temperatures? - JR1 - 12-20-2015
I can only say that 50F is plenty for shellac. I buy flake/seed/button from these guys and mix my own that way I know what I am getting. I've wiped shellac down to 20F and sprayed close to 0F. I've no idea on lacquer as after some tests I don't use it.
Re: Spray shellac & lacquer - acceptable lowest temperatures? - fredhargis - 12-21-2015
I've sprayed lacquer as low as 25ยบ outside, let it sit a few minutes and bring it in with no problems. Both are evaporative finishes...as long as the solvent can evaporate it's not too cold. I'll spray shellac inside, but not lacquer...I always spray it outdoors.
Re: Spray shellac & lacquer - acceptable lowest temperatures? - Joel H. - 12-21-2015
fredhargis said:
I'll spray shellac inside, but not lacquer...I always spray it outdoors.
+100
I have sprayed the lacquer in my garage - whoa! Never again. If Fred says it can be sprayed down to 25 degrees, I believe him. I have sprayed lacquer down to 60 outside in the sunshine without problem It looks like we may have some warm weather this week (Christmas week) - but very high humidity & rain here in Tenn. (your weather is usually a day behind ours).
Joel
Re: Spray shellac & lacquer - acceptable lowest temperatures? - Bill Wilson - 12-21-2015
Don't know about lacquer, but I've successfully sprayed shellac outside in temps below 32 degrees. As long as the air is dry, I don't think temperature is a problem with shellac.
Re: Spray shellac & lacquer - acceptable lowest temperatures? - giradman - 12-21-2015
Thanks all for your useful and experienced responses - I've used the spray shellac outside when chilly and then brought the project in immediately; not sure about the spray lacquer (the directions on the can gives no useful information except to say the finish may whiten if the humidity is to high) - being in North Carolina, I'll try to spray when the outside temps get to 50F or above - no deadline, so can wait until a 'balmy' day or two! Comments much appreciated - Dave
Re: Spray shellac & lacquer - acceptable lowest temperatures? - Howard Acheson - 12-31-2015
Evaporative solvent based finishes like lacquer and shellac can be applied at very low temperatures. Drying may be slowed but it will still dry in less than an hour.
I have sprayed by at or below freezing with no negative effects except for the slightly slower drying times.
Re: Spray shellac & lacquer - acceptable lowest temperatures? - giradman - 01-04-2016
Howard Acheson said:
Evaporative solvent based finishes like lacquer and shellac can be applied at very low temperatures. Drying may be slowed but it will still dry in less than an hour.
I have sprayed by at or below freezing with no negative effects except for the slightly slower drying times.
Thanks Howie for the comments above - this weekend in Piedmont, NC, the daytime temps hit just above 50F, so I had no problem w/ those rattle cans - good to know that the temps can be lower because I have a few more projects to do - Dave